BLOG

Cleaning Car Frames

It would be best to have the following supplies available; Both Heavy and Light Liquid Degreaser, some sheets of Plastic used in painting and for your body protection we recommend; goggles which protect your eyes, rain Gear and Plastic Boots.

When you hit areas of where the frame comes together or where there are holes in the frame, which have paint chips or rust, you will want to hit these with the zero tip. Be careful to wear eye protection because the deflected water will still be moving very fast. The non deflected water if it hits your body can easily break the skin.

It is best to work on one section at a time. It is also important to contain the dirty water flow once you start using the chemicals for cleaning. Many times you will be surprised at how well the pressure washer does without any degreaser or with light degreaser. To do this job correctly follow this easy step by step guide. First check the water flow to make sure dirty water will not enter gutter then lay down the plastic in the section to be cleaned and use two by fours to put under the outer …

Repair a Windshield

The windshield is a two-layered laminated glass. This laminate is made of vinyl plastic which is very strong. The windshield accounts for nearly 20{08ca10d30646d00694ecfbb2fda19d22c6ce1a9566c60537bc4c0733a053b050} of the strength of the car. It plays a major role in keeping you safe. With the advancement in technology, the process of placing the windshield has become a computer controlled process. It has been designed to work with the other safety devices in the car. For instance, the airbags need a strongly bonded windshield in order to work correctly. Thus, it is important to get even a tiny crack on the windshield repaired. Ignoring it may put the life of the driver in danger.

The costs for replacing the entire windshield costs $300 and repairing a crack or a chip in the windshield could cost around $100 or lesser. There are also many kits available for you to repair the windshield yourself. These kits can be purchased from Amazon and in large stores that sell auto parts such as Wal-Mart, Kmart, Sears, and AutoZone. The kit will consist of the adhesive seal, windscreen repair resin, curing film, pedestal and a safety razor. Once you have the kit, park your car in your garage or somewhere …

UTE Maintenance

The first thing is to locate your dipstick, in a manual vehicle there is only one, but an auto will also have one for the transmission fluid so be sure the verify which one it is engine oil before filling. (It should say on the top). It is usually colored plastic knob that is formed into a loop or has a rounded top that your finger can fit through to make it easier to pull out.

Use a clean cloth or paper towel to wipe the end clean so you can inspect it and tell where the fill and empty lines.

Insert the dipstick back into the engine, then pull it out again. The dipstick will go down into the engine sump and tells you how much oil is there.

You can then read how much oil is there. The ideal oil level is at the full mark. If the oil is above the halfway mark it is safe to leave it as there will be enough oil, but take note of this and check the level again after a few 100km.

If it is below the halfway mark, then add the recommended oil for your engine. (Diesel engine oil …

Car Wrap

1) A quick and easy face lift:

Breathe new life into the appearance of their car by simply changing the colour. Many companies come with a standard range of colours and even some rare, unique materials that can be wrapped on cars.

2) Maintaining a cars residual value:

As appealing as vinyl sounds to car customisation fanatics, it’s also a practical way of ensuring your car’s paint job stays as new as the day it rolled off the production line, and had its VIN number engraved. Vinyl, or more specifically Paint Protection Film, can ensure that your car can be resold and that you get a higher price, as the vinyl often takes the brunt of stone chips, scratches and weather.

3) Business Use

Car wrapping isn’t just reserved for those looking to make their car a standout vehicle. It’s also a massively popular method of advertising for business owners, who often have their work vehicles wrapped in special vinyl and graphics with their business names and logos, all to help them in the promotion of their business, plus they also use it as a tax write off for their business’

4) Individual Styling

Car wrapping is by far the …

Modifying a Car

www.AutoVillage.co.uk

  • Make sure that you have all your tools on hand. This includes sandpaper, electric sandpaper, masking tape, newspapers, air compressors, and spray guns. Also consider weather conditions such as sunshine, wind, and rain.
  • Make sure that you have the correct chemicals for the paint such as thinners, primer, undercoat, and top coat. All these are necessary to prolong the life of the paint job.
  • Remove all the dust in your work area to prevent particles from landing on the wet paint. Particles will destroy the smooth finish. You also need to clean the car to remove all grease and road contaminants.
  • Never forget to wear a face mask, goggles and gloves to avoid getting the chemicals on your skin. These items will also protect you from the particles that come off when you sand current enamel off the Used Cars.
  • Sand the car in circular motions for a uniform surface. The more uniform the better the end result. Once you have finished with sanding the chassis, apply thinners onto a cloth and wipe the surface. Thinners will get the remaining paint off.
  • Priming the surface provides a good base coat to prolong the life of the paint job. It

Mobile Auto Detailing

A little soap is good for the environment, but we are not allowed to let soap run into a storm drain. While it is true that there are harsh chemicals and detergents that are currently used by industry and homeowners that should never be allowed free to run into our ecosystem, most basic soap won’t hurt anything. As a matter of fact, they actually help break down other unwanted contaminants so they can be further filtered by mother earth’s soil and diluted by her abundant water. Most mobile auto detailer’s soaps are perfectly harmless. Unfortunately, no matter how good or biodegradable these soaps are, the law reads nothing but ‘domestic potable water’ goes into the storm drains.

Non-spray products such as silicon for bumpers, wax, adhesive remover, etc. are major environmental problems because they contain dastardly chemicals. You must realize these chemicals do not go into the environment during the washing of the vehicle; therefore, they do not constitute a pollution discharge. Whatever you do, do not pour out a 55-gallon drum of this type product into the gutter in front of your house.

Here is a sad story of what happens when there is an unscrupulous manufacturer tries to …

Clean a Car Battery

  • You will need to determine the configuration of the terminals as there are different types. Determining the configuration will help you to pick the correct wrench to loosen the nuts that keep the cables in place.
  • Now, you need to unfasten the cables (negative and positive respectively) from their posts. Twisting might be necessary to release the cable as they might have been put on quite tightly.
  • Before continuing with the process, checking for leaks and cracks is a must. Car batteries lose acid and could corrode the rest of the components of the engine. If you do see any cracks or leaks, the battery must be replaced.
  • Cables and clamps could also have cracks along the wiring. They could easily be replaced with new parts.
  • This is the part where a basic household item is required to clean the battery: baking soda. The ratio to mix baking soda and hot water in a small container is 1:17. This is usually a tablespoon of baking soda and a cup of hot water.
  • Then it is time for the scrubbing and cleaning. A toothbrush would be ideal for this process so that your hands don’t come into contact with the battery.

Paint Protection Film

Now, there are preventative measures, such as ensuring it’s well maintained, cleaning it, and driving carefully. But, what about factors you can’t control. For instance, a small piece of gravel that’s been kicked up by a semi-trailer, and ricochets off your bonnet, or roof, or mirror, or any part. This is where paint protection film steps in. Its purpose is similar to that of bulletproof glass (please do not shoot at a car with paint protection film). It’s job is to absorb the impact by acting as a barrier. Its composition is made up of a polyurethane film, not too far off the stuff used on armoured glass. The use of paint protection film is to ensure that little to no harm comes to your vehicle. I mean, it’s not going to protect you if you another car slams into you at 60km/h. That job is reserved for your seatbelt and airbags. It will, however, stop those unruly scratches, stone chips, and even minor abrasions. It even protects your paint work from pollutants and contaminants, such as bird droppings, tree sap, dirt, dust and other unfavourable things that could damage your paint. Paint protection film can save you a tonne …

Dual Clutch Transmission

The main disadvantage of having a dual clutch transmission in your car is the price. Replacing this type of system requires skill. It is a complicated clutch kit system that needs electronic and mechanical knowledge.

The dual clutch transmission is also known as a semi-automatic transmission. This transmission provides the functionality of two manual transmissions in one. Once the driver changes from one gear to another gear in a regular stick shift car, the first thing that should be done is to press the clutch pedal. This will disconnect the engine from the gearbox and at the same time, it will disconnect current from the transmission.

The driver uses the stick shift to select a new gear as speed increases and torque decreases, which will involve moving a toothed collar from a gear wheel to another gear wheel which has different sizes. Furthermore, there is a device called the synchronizer that helps match the gears so that there is no grinding. Mechanically, it makes sure that the gears are engaged.

The clutch kit includes a disc or grip pressure plate; although some clutch kits have pilot bushings or pilot bearings. All these items have specific functions that are included in …

Brake Shoe Bonding

Was it squealing? That could be as simple as the pads wearing down. No big deal, right? Was the pedal sticking? That’s a little bit of a bigger issue because that is a sign of a faulty master cylinder. It is safe to say that if they lock up with just a slight bit of pressure, you need to get to mechanic as soon as possible.

Since brakes are one of the most important parts on a car, you need to be cautious if you notice anything strange. If you can’t stop or slow down, how are you going to drive? A typical car has two forms of braking; the primary one, which is your pedal, is used when the car is running and on the road. While the secondary one is usually referred to as the emergency or parking brake and is used to keep the car stationary, or in case of an emergency. It is important to perform routine check-ups and service your vehicle regularly to avoid having to use your emergency brake.

Assuming your car has drums as opposed to discs, you may need to add shoes to your brake repair to-do list. The shoe is typically …